HP C9K59UT#ABA Instrukcja Użytkownika

HP ProBook 4540s Notebook PCHP ProBook 4440s Notebook PCHP ProBook 4441s Notebook PCMaintenance and Service Guide

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc)Panel All display assemblies include 2 wireless local areanetwork (WLAN) antennas

Hard drive extension board (4540s models only)Description Spare part numberHard drive extension board 683487-001Before removing the hard drive extensi

2. Pull the hard drive extension board straight away from the system board.Reverse this procedure to install the hard drive extension board.Component

Power cableThe power cable is included in the Cable Kit, spare part number 683477-001 for 4540s models,683640-001 for 4440s/4441s models.Before removi

3. Lift the power cable assembly from the computer (2).Reverse this procedure to install the power cable.Latch assemblyNOTE: The Latch Kit includes th

g. Speaker assembly (see Speaker assembly on page 76)h. System board (see System board on page 85)NOTE: The latch mechanism includes a small spring. N

Display assemblyAll display assemblies include WLAN antenna transceivers and cables. WWAN models include 2WWAN antenna transceivers and cables.For a l

4. Position the computer upside down.5. Remove the WWAN antenna cables (1) and the WLAN antenna cables (2) from the routing pathon the bottom of the c

10. Lift the display assembly straight up and remove it (2).CAUTION: When installing the display assembly, be sure that the wireless antenna cables ar

11. If you need to remove the hinge covers from the display hinges, pull the hinges straight up andoff the display to remove them.Display hinge covers

13. Flex the top (1) of the bezel, the inside edges of the left and right sides (2), and then the bottom(3) of the bezel until it disengages from the

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc) Supports the following drives:● 750-GB, 7200-rpm or 5400-rpm● 640-GB, 5400-rpm●

15. If it is necessary to replace the webcam module (shown in the following image) or microphonemodule from the display enclosure, disconnect the cabl

17. Remove the display hinges and panel from the display enclosure.18. Disconnect the display panel cable by rotating the display enclosure (1), lifti

20. Remove the display hinges (2).Display hinges are available in the Display Hinge Kit using spare part number 683480-001 for4540s models and 683643-

5 Computer Setup (BIOS) and AdvancedSystem DiagnosticsUsing Computer SetupComputer Setup, or Basic Input/Output System (BIOS), controls communication

To exit Computer Setup menus, choose one of the following methods:●To exit Computer Setup menus without saving your changes:Click the Exit icon in the

Updating the BIOSThe next sections describe different ways of updating the BIOS.Downloading SoftPaqs to update the BIOSMost BIOS updates on the HP web

5. Locate the .sig file in the ROM.cab file and rename it with the same prefix as the .bin file (forexample, 68CDD.sig). Copy the renamed file to the

Downloading a BIOS updateCAUTION: To reduce the risk of damage to the computer or an unsuccessful installation, downloadand install a BIOS update only

Main menuSelect To do thisSystem information●View and change the system time and date.● View identification information about your computer.● View spe

You can view system information and error logs in the Advanced System Diagnostics window.To start Advanced System Diagnostics:1. Turn on or restart th

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc) Supports the following WLAN formats:● Ralink 802.11 b/g/n 1×1● Atheros 802.11 b

6 SpecificationsComputer specifications Metric U.S.Dimensions, 4540s modelsLength 25.6 cm 10.1 inWidth 37.5 cm 14.8 inHeight (front to rear) 2.9 to 3.

Metric U.S.Operating 125 g, 2 ms, half-sineNonoperating 200 g, 2 ms, half-sineRandom vibrationOperating 0.75 g zero-to-peak, 10 Hz to 500 Hz, 0.25 oc

35.6-cm (14.0-in), HD display specifications Metric U.S.Active diagonal size 35.6-cm 14.0-inResolution 1366x768 (HD)Active area 309.399x173.952PPI 112

Hard drive specifications 750-GB* 640-GB* 500-GB* 320-GB*DimensionsHeight 9.5 mm 9.5 mm 9.5 mm 9.5 mmWidth 70 mm 70 mm 70 mm 70 mmWeight 115 g 101 g 1

DVD±RW and CD-RW SuperMulti DL Combo DrivespecificationsApplicable disc Read:CD-DA, CD+(E)G, CD-MIDI, CD-TEXT, CD-ROM, CD-ROM XA, MIXED MODE CD, CD-I,

Blu-ray Disc ROM with SuperMulti DVD±R/RW DL DriveApplicable disc Read: Write: CD-DA, CD+(E)G, CD-MIDI, CDTEXT,CD-ROM, CD-ROM XA,MIXED MODE CD, CD-I,

Specification information in Device ManagerDevice Manager allows you to view and control the hardware attached to the computer, as well asprovides har

7 Backup and recoveryTo protect your information, use Windows Backup and Restore to back up individual files and folders,back up your entire hard driv

Creating recovery media with HP Recovery Disc CreatorHP Recovery Disc Creator is a software program that offers an alternative way to create recoverym

Backing up your informationRecovery after a system failure is as good as your most recent backup. Immediately after softwaresetup, you should create s

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc)Power requirements Smart AC adapter with localized cable plug support(3-wire plug

Performing a system recoveryIn case of system failure or instability, the computer provides the following tools to recover your files:●Windows recover

Using f11 recovery toolsCAUTION: Using f11 recovery tools completely erases hard drive contents and reformats the harddrive. All files you have create

After the repair is completed:1. Eject the Windows 7 operating system DVD, and then insert the Driver Recovery disc.2. Install the Hardware Enabling D

8 Power cord set requirementsThe wide-range input feature of the computer permits it to operate from any line voltage from 100 to120 volts ac, or from

Requirements for specific countries and regionsCountry/region Accredited agency Applicable note numberArgentina IRAM 1Australia SAA 1Austria OVE 1Belg

Country/region Accredited agency Applicable note numberThe United States UL 21. The flexible cord must be Type HO5VV-F, 3-conductor, 0.75mm2 conductor

9 RecyclingBatteryWhen a non-rechargeable or rechargeable battery has reached the end of its useful life, do notdispose of the battery in general hous

Perform the following steps to disassemble the display assembly:1. Remove all screw covers (1) and screws (2) that secure the display bezel to the dis

4. Disconnect all display panel cables (1) from the display inverter and remove the inverter (2).5. Remove all screws (1) that secure the display pane

10. Remove the display panel frame (2) from the display panel.11. Remove the screws (1) that secure the backlight cover to the display panel.12. Lift

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc) Windows 7 Professional 32 with Microsoft Office2010 Personal (Japan only)√√

15. Remove the backlight cables (1) from the clip (2) in the display panel.16. Position the display panel upside-down.WARNING! The backlight contains

18. Remove the backlight from the backlight frame.19. Disconnect the display panel cable (1) from the LCD panel.20. Remove the screws (2) that secure

IndexAAC adapter light 15AC adapter, spare part numbers29, 31advanced system diagnostics110antennasdisconnecting 52, 54audio boardremoval 81spare part

Eelectrostatic discharge 38embedded numeric keypad,identifying 13esc key, identifying 12, 13Ethernet, product description 3external media cards, produ

optical drive protective insertillustrated 26optical drive, identifying 16Ppacking guidelines 39plastic parts 36Plastics Kit, spare part number26, 33p

webcam moduleremoval 102spare part number 25webcam, identifying 8Windows 7 operating systemDVD 123Windows applications key,identifying 12, 13Windows B

Category Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc) WWAN module √ √ Keyboard √√√√7

2 External component identificationDisplayComponent Description(1) WWAN antennas (2)* (select models only) Send and receive wireless signals to commun

Component Description(6) Internal display switch Turns off the display or initiates Sleep if the display is closedwhile the power is on.NOTE: The disp

LightsComponents Description(1)Power light ●On: The computer is on.● Blinking: The computer is in the Sleep state.●Off: The computer is off or in Hibe

Buttons, speakers, and fingerprint reader (select models only)Component Description(1)Power button●When the computer is off, press the button to turn

© Copyright 2012 Hewlett-PackardDevelopment Company, L.P.Bluetooth is a trademark owned by itsproprietor and used by Hewlett-PackardCompany under lice

Component Description(4)Wireless button Turns the wireless feature on or off but does not establish awireless connection.(5) Fingerprint reader (sel

Model 4440s/4441sComponent Description(1) esc key Displays system information when pressed in combinationwith the fn key.(2) fn key Executes frequ

FrontComponent Description(1)Drive light ●White: The hard drive is being accessed.● Amber: HP 3D DriveGuard has temporarily parked thehard drive.NOTE:

LeftComponent Description(1)Security cable slot Attaches an optional security cable to the computer.NOTE: The security cable is designed to act as ad

RightComponent Description(1)USB 2.0 ports (2) Connect optional USB devices. For more information aboutUSB devices, see the HP Notebook Reference Guid

3 Illustrated parts catalogService tagWhen ordering parts or requesting information, provide the computer serial number and modeldescription provided

Computer major componentsModel 4540sFigure 3-1 Model 4540s18 Chapter 3 Illustrated parts catalog

Item Description Spare part number(1) Display panel 39.6-cm (15.6-inch) HD, anti-glare, without webcam 683481-001 39.6-cm (15.6-inch) HD, anti-gla

Item Description Spare part number(16) WWAN modules Ericsson F5321 HSPA+ with GPS 668969-001 Sierra MC8355 HSPA/CDMA with GPS 634400-001(17) Memo

Item Description Spare part number 320-GB, 7200-rpm 641672-001(23) Bottom door 690978-001Computer major components 21

Safety warning noticeWARNING! To reduce the possibility of heat-related injuries or of overheating the computer, do notplace the computer directly on

Model 4440s/4441sFigure 3-2 Model 4440s/4441s22 Chapter 3 Illustrated parts catalog

Item Description Spare part number(1) Display panel 35.6-cm (14.0-inch), anti-glare, without webcam 683644-001 35.6-cm (14.0-inch), anti-glare, wi

Item Description Spare part number Atheros AR9485 802.11b/g/n 1x1 WiFi Adapter 675794-001(14) WWAN modules Ericsson F5321 HSPA+ with GPS 668969-0

Item Description Spare part number 128-GB solid-state drive 684253-001(19) Heat sink (includes replacement thermal material) For use in models wit

Plastics KitItem Description Spare part number Plastics Kit for use in 4540s models 683501-001 Plastics Kit for use in 4440s/4441s models 683662-001

Cable KitItem Description Spare part number Cable Kit for use in 4540s models 683477-001 Cable Kit for use in 4440s/4441s models 683640-001(1) Batte

Mass storage devices Description Spare part number(1) Hard drives 750-GB, 7200-rpm 633252-001 750-GB, 5400-rpm 634250-001 640-GB, 5400-rpm 669300-001

Miscellaneous partsDescription Spare part numberAC adapters65-W AC adapter 693711-00165-W AC adapter for use in India and the People's Republic o

Description Spare part numberNylon case 612757-001Top load case 679921-001Sequential part number listingCSR flag designations:A = MandatoryB = Optiona

Spare partnumberCSRflagDescription679921-001 A Top load case693711-001 A 65-W AC adapter693712-001 A 90-W AC adapter693713-001 A 90-W AC adapter for u

iv Safety warning notice

Spare partnumberCSRflagDescription682417-001 N Intel Core i3 processor, 3110M, 2.3-GHz, 3-MB L3 cache (include thermal material)683475-001 N Audio boa

Spare partnumberCSRflagDescription683491-281 A Keyboard for use in 4540s models in Thailand683491-291 A Keyboard for use in 4540s models in Japan68349

Spare partnumberCSRflagDescription683642-001 N Display bezel for use with HP ProBook 4440s/4441s models without a webcam683643-001 N Display Hinge Kit

Spare partnumberCSRflagDescription691111-001 A DVD±RW and CD-RW Super Multi Double-Layer Combo Drive (includes bezel, bracket, and screws)692428-001 N

4 Removal and replacement proceduresPreliminary replacement requirementsTools requiredYou will need the following tools to complete the removal and re

Cables and connectorsCAUTION: When servicing the computer, be sure that cables are placed in their proper locationsduring the reassembly process. Impr

Grounding guidelinesElectrostatic discharge damageElectronic components are sensitive to electrostatic discharge (ESD). Circuitry design and structure

Packaging and transporting guidelinesFollow these grounding guidelines when packaging and transporting equipment:● To avoid hand contact, transport pr

Equipment guidelinesGrounding equipment must include either a wrist strap or a foot strap at a grounded workstation.● When seated, wear a wrist strap

Component replacement proceduresThis chapter provides removal and replacement procedures.There are as many as 95 screws and screw locks, in 15 differe

Table of contents1 Product description ...

BatteryDescription Spare part number9-cell, 93 WHr, 2.8 Ah Li-ion battery 633809-0016-cell, 47 WHr, 2.2 Ah Li-ion battery 633805-001Before disassembli

Using the optional security screwUse the optional security screw to lock the service door to the bottom of the computer. When not inuse the security s

Bottom doorDescription Spare part numberBottom door for use in 4540s models 690978-001Bottom door for use in 4440s/4441s models 690979-001Before disas

SIMNOTE: This section applies only to computer models with WWAN capability.NOTE: The SIM is provided by the end-user as a security measure for the WWA

Optical driveNOTE: All optical drive spare part kits include an optical drive bezel, bracket, and screws.Description Spare part numberFor use in 4540s

4. Remove the optical drive (3) from the computer.Reverse this procedure to install an optical drive.Component replacement procedures 47

Hard driveNOTE: All hard drive spare part kits include a hard drive bracket and screws.Description Spare part number750-GB, 7200-rpm hard drive 633252

3. Pull the Mylar tab on the hard drive (2) toward the side of the computer to disengage the harddrive from the connector, and then lift the hard driv

6. Lift the top of the Mylar cover (2) from the drive, and then remove the cover from the hard drive(3).Reverse this procedure to reassemble and insta

7. Click the link for the most recent BIOS.8. Click the Download button, and then follow the on-screen instructions.Before removing the memory module,

Plastic parts ... 36Cables and connectors ...

WWAN moduleCAUTION: The WWAN module and the WLAN module are not interchangeable.Description Spare part numberEricsson F5321 HSPA+ with GPS 668969-001S

4. Remove the WWAN module (3) by pulling the module away from the slot at an angle.NOTE: WWAN modules are designed with a notch to prevent incorrect i

WLAN/Bluetooth combo cardThe computer uses a card that provides both WLAN and Bluetooth functionality.CAUTION: The WLAN module and the WWAN module are

4. Remove the WLAN module (3) by pulling the module away from the slot at an angle.NOTE: WLAN modules are designed with a notch to prevent incorrect i

KeyboardNOTE: For a detailed list of available keyboards, see Sequential part number listing on page 30.Description Spare part numberKeyboard for use

3. For model 4440s/4441s, remove the two Phillips PM2.5×6.0 screws that secure the keyboard tothe computer.4. Position the computer right-side up with

8. Rotate the keyboard until it rests on the palm rest (1), and then disconnect the keyboard cableby lifting the keyboard connector latch (2), and the

Heat shieldDescription Spare part numberHeat shield for use in 4540s models 687696-001Heat shield for use in 4440s/4441s models 683497-001Before remov

6. Remove the heat shield from the computer (4).7. For model 4440s/4441s, remove the three Phillips PM2.0×3.0 screws (1) that secure the heatshield to

FanDescription Spare part numberFan for use in 4540s models 683484-001Fan for use in 4440s/4441s models 683651-001Before removing the fan, follow thes

Starting Computer Setup ... 105Navigating and selecting

4. Remove the fan from the system board (3).Reverse this procedure to install the fan.NOTE: To properly ventilate the computer, allow at least a 7.6-c

Heat sinkAll heat sink spare part kits include replacement thermal material.Description Spare part numberFor use in 4540s models: Heat sink for use i

3. Lift the left side of the heat sink up at an angle (2), and then pull it away from the side of thecomputer to remove it (3).4. To remove the UMA he

NOTE: For UMA models, thoroughly clean thermal material from the surface of the system board(1) and heat sink (2) each time you remove the heat sink.

ProcessorNOTE: All processor spare part kits include replacement thermal material.Description Spare part numberIntel Core i7 processor, Quad Core: 36

Remove the processor:1. Position the computer upside-down.2. Use a flat-bladed screwdriver to turn the processor locking screw (1) one-half turncounte

3. Disconnect the power from the computer by first unplugging the power cord from the AC outlet,and then unplugging the AC adapter from the computer.4

3. For 4440s/4441 models, disconnect the following cables from the system board:(1) Function board/Power button board cable(2) Finger print reader boa

5. For 4540s models, remove the following screws that secure the top cover to the computer:(1) 4 rubber screw covers from the corners of the computer(

6. For 4440s/4441s models, remove the following screws that secure the top cover to thecomputer:(1) 4 rubber screw covers from the corners of the comp

Index ...

7. For 4540s models, remove the following screws that secure the top cover to the computer:(1) 2 Phillips PM2.0×2.5 screws from the optical drive bay(

9. Position the computer upright.10. For 4540s models, remove the two 2 Torx T8M2.5×6.0 screws screws that secure the top coverto the computer.11. For

12. Turn the computer upright and open it as far as possible.13. Pry the top of the top cover loose from the computer (1).14. Lift the top cover up sl

Fingerprint reader boardNOTE: Fingerprint assembly spare part kits include cable, bracket, and screws.Description Spare part numberFingerprint reader

4. Remove the reader and cable assembly from the top cover (4).Reverse this procedure to install the fingerprint reader board.Speaker assemblyNOTE: In

4. Remove the battery (see Battery on page 42).5. Remove the following components:a. Bottom door (see Bottom door on page 44).b. Keyboard (see Keyboar

9. Remove the two broadhead PM2.0×3.0 screws (2) that secure the speakers to the computer,and the remove the speakers from the computer (3).Reverse th

Function board/Power button board assemblyDescription Spare part numberFunction board/Power button board assembly for use in 4540s models (includes ca

4. Remove the power button board from the top cover. (3).Reverse this procedure to install the function board/power button board assembly.80 Chapter 4

Audio boardDescription Spare part numberAudio board (includes cable) 683475-001Before removing the audio board, follow these steps:1. Shut down the co

1 Product descriptionCategory Description 4540s(UMA)4540s(Disc)4440s(UMA)4440s/4441s(Disc)Product Name HP ProBook 4540s Notebook PC √√ HP ProBook

Reverse this procedure to install the audio board.USB connector assemblyThe USB connector assembly is included in the Cable Kit, spare part number 683

4. Remove the two Phillips PM2.5×4.5 screws (4440s/4441s models) (3) that secure the USBconnector to the computer.NOTE: Model 4540s has only one screw

Battery cableThe battery cable is included in the Cable Kit, spare part number 683477-001 for 4540s models,684640-001 for 4440s/4441s models.Before re

System boardNOTE: All system board spare part kits include replacement thermal material.Description Spare part numberFor use in 4540s models with: UM

When replacing the system board, be sure to remove the following components from the defectivesystem board and install on the replacement system board

6. Lift the right side of the system board up at an angle (2), and then lift it up and off the computer.7. For 4440s/4441s models, remove the two Phil

RTC batteryDescription Spare part numberRTC battery 683502-001Before removing the RTC battery, follow these steps:1. Shut down the computer. If you ar

3. Lift the battery from the system board (2).Reverse this procedure to install the RTC battery.Component replacement procedures 89

Optical drive extension board (4540s models only)Description Spare part numberOptical drive extension board 683498-001Before removing the optical driv

2. Pull the optical drive extension board straight away from the system board.Reverse this procedure to install the optical drive extension board.Comp